Product ID:SILICONE ALKYD COPOLYMER ENAMEL #16187 GRAY
MSDS Date:08/01/2000
FSC:8010
NIIN:01-356-2940
Status Code:A
MSDS Number: CLPRF

Emergency Phone: 800-424-9300

Info Phone: 206-244-8844

Preparer: ERNEST CARTER

Cage: 6F266

Telephone: 206-244-8844

Cage: 6F266

MINERAL SPIRITS

CAS: 8032-32-4

RTECS: OI6180000

ACGIH TLV: 1370 MG/M3;300 PPM

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Effects of Overexposure:SKIN: THIS MATERIAL MAY CAUSE IRRITATION.
SENSITIZATION, OR DEFATTING OF SKIN UPON PROLONGED OR REPEAETD
CONTACT. INHALATION: EXCESSIVE EXPOSURE TO VAPORS OR SPRAY MIST CAN
RESULT IN HEADACHE, DIZZINE SS, NAUSEA AND LOSS OF CONSCIOUSNESS.
EYES: THIS MATERIAL MAY BE AN EYE IRRITANT.

First Aid:SKIN: WASH WITH SOAP AND WATER. REMOVE AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH WITH LARGE
QUANTITIES OF WATER FOR 15 MINUTES AND SEEK MEDICAL ATTENTION.
SWALLOWING: IF INGESTED DO NOT INDUCE VOMITING; KEEP PERSON WARM
AND QUIET AND GET MEDICAL ATTENTION. INHALATION: REMOVE VICTIM TO
FRESH AIR IMMEDIATELY. IF RESPIRATORY SYMPTOMS DEVELOP, SEEK
MEDICAL ATTENTION AT ONCE.

Flash Point Method:TCC
Flash Point:=41.7C, 107.F
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, OR WATER FOG.
Fire Fighting Procedures:FIREFIGHTERS AND OTHERS EXPOSED TO VAPORS OR
PRODUCTS OF COMBUSTION SHOULD WEAR SELF CONTAINED BREATHING
APPARATUS. EVACUATE AREA OF UNPROTECTED PERSONNEL. WEAR PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM AN EXPLOSIVE MIXTURE IN
AIR AND MAY BE IGNITED BY SPARKS, PILOT LIGHTS, ETC. CLOSED
CONTAINERSMAY RUPTURE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. ABSORB SPILL WITH AN ABSORBENT MATERIAL SUCH AS SAWDUST,
VERMICULITE OR SAND PLACE MATERIAL INTO A CLOSED CONTAINER. IF
LARGE SPILL, DIKE AREA TO PREVE NT THIS MATERIAL FROM ENTERING
WATER SYSTEMS OR SEWERS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP.

Handling and Storage Precautions:AVOID PROLONGED OR REPEAETD INHALATION
OF HEATED VAPORS OR SPRAY MIST. KEEP AWAY FROM HEAT OR OPEN FLAME.
THIS MATERIAL MAY CAUSE SENSITIZATION, DO NOT GET IN EYES, ON SKIN
OR CLOTHING. DO NOT ALLOW C ONTAMINATED CLOTHING TO CONTACT SKIN.
DO NOT WELD ON F KEEP CONTAINERS CLOSED WHEN NOT IN USE.

Respiratory Protection:A CANISTER TYPE RESPIRATOR MUST BE WORN TO
PREVENT THE INHALATION OF VAPORS OR SPRAY MIST WHEN THE TLV OR PEL
IS EXCEEDED.
Ventilation:GENERAL VENTILATION IS REQUIRED.
Protective Gloves:CHEMICAL RESISTANT NITRILE, NEOPRENE OR RUBBER GLOVES
REQUIRED.
Eye Protection:WEAR FACE SHIELD OR CHEMICAL GOGGLES.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:307-387 F
Vapor Pres:2.6 MMHG @20 C
Vapor Density:HEAVIER
VOC Pounds/Gallon:340
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:GRAY LIQUID, MILD ODOR
Percent Volatiles by Volume:45%

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES AND EPOXY HARDENERS
UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:COMBUSTION CAN YIELD CARBON MONOXIDE
AND TOXIC VAPORS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL AGENCIES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.